Wanted Windshield Glass for 1986 Sylvan 22 Offshore

[JTM203SOUTH]

Looking for windshield glass and/or windshield parts for 1986 Sylvan 22 Offshore . This is for the windshield which sets above the Cuddy Cabin. Will consider a complete windshield.

 

PM me or call 413-519-3509

 

Thanks , Jack

[thork9]

I have a 1985 Starcraft islander, I replaced my windshield,very similar to yours. As long as frame is ok, I saved all the rubber around window. Removed all damaged glass replaced with 1/8 in thick paneling as a template. Put it together and make sure it all fits. I had about a 1/2 in gap around th frame inside . I took pattern to my local glass shops. and they cut glass using my template, I got tinted glass. They then sent glass out to be tempered. I replaced and it's better than new. Cost me $200.00 wasn't hard gust make the template as long as your glass was flat no problem. I checked all over the Internet and couldn't find anything boat to old. No one sells the moldings , rubber etc so save . My glass was originally made from the Starcraft factory which the bought the glass and frames from TAYLOR MADE co. I live 20 min from them and they stated way to old.

[JTM203SOUTH]

Thanks thork9,

 

  I've spent a lot of time on the internet with much the same result. The side vent windows are the principal problem - Port side broke and gaskets for both sides are shot. if I can't find the parts , I may simply follow your advice and simply install them as non-opening.

 

  Thanks again,  Jack

[rolmops]

Try and check some boat graveyards.

[JTM203SOUTH]

Thanks, rolmops

 

 I've contacted several that I found on the internet without success. Will continue to look. 

 

  Jack

[vetting]

Are there 2 pieces of glass and one is currently broken?  I had that situation so I took the good one out and took it to a glass shop and they made a mirror image of that one for less than $200 and it was a special order vintage green tint glass.  

[rolmops]

Here is a list

 

Salvage Yards

 

 

Salvage yards:
sea-way.com
outboard-parts.com
laingsoutboards.com
tcoutboard.com
fairwindsmarina.com
salvagemarine.com
marinepartsoutlet.com
Superior Marine (800-338-9281)
trixieslanding.com Trixie’s Landing, Bayville, NJ 732-269-5838
americanoutboard.com
piratemarinesalvage.com/
Don's marine Salvage, 5601 126th Avenue North Clearwater, FL 33760 - (727) 576-8577
timsoutboard.com
http://www.shipwreckusedparts.com/aboutus.html
http://www.mmsalvage.com/
http://www.outboardjunkyard.com/snow...BOUT-US-02-04/
http://forums.iboats.com/johnson-evi...e1-438822.html

Edited September 1, 2016 by rolmops

[JTM203SOUTH]

Thanks , rolmops

 

 You list several that i wasn't aware of. I'll get busy.

 

  Jack

[thork9]

I did the whole front windshield for $200 not the sides they will be a lot cheaper .